Control Modules - Design And Function - 1 Of 3
- Accessory Electronic Module (AEM) (2001-2006)
- Active On Demand Coupling (AOC) (2003-2004)
- Design
- Diagnostic Functions
- Description Of Parameters
- Parameters, Status
- Parameters, Value
- Differential Electronic Module (DEM), Voltage
- Central Electronic Module (CEM), Voltage
- Oil Temperature
- Oil Pressure
- Solenoid, Current
- Pump, Current
- Wheel Speed
- Number Of Detected Errors
- Power Supply, Differential Electronic Module (DEM)
- Power Supply, Pump Motor
- Power Supply, Pressure Reducing Valve
- ECU-Temperature
- Downloading Software And Replacing The Control Module
- Function
- System Overview
- Additional Heater And Parking Heater (Combustion PREHEATER Module) (1999-2004)
- Alarm (1999-2004)
- Alarm (2005-2006)
- Audio Module (AUM) (1999-2006)
- Battery (All)
- Design And Function
- Introduction
- Principle
- Function
- A Battery Works As Follows
- Battery Types
- The Construction Of The Battery
- The Construction Of The Cells
- Discharge
- Charging
- Gas Build Up
- Self-Discharge
- Acid Density
- State Of Charge, SOC
- Capacity
- Battery Service Life
- High Temperatures
- Cycling
- Low Electrolyte Level
- Deep Discharging
- Incorrect Charging
- Sulfation
- Corrosion
- Vibrations
- Terminology
- AGM-Battery
- Active Material
- Ampere (A)
- Ampere Hours (Ah)
- Battery Acid
- Battery Water
- CCA
- Cell
- Cycle
- Din
- Electrical Current
- Electrode
- Electrolyte
- Separator
- Grid
- Capacity
- Corrosion
- Short-Circuit
- Cold Cranking Amperes
- Charging
- State Of Charge, SOC
- Direct Current, DC
- Plate
- Plug (Not Maintenance-Free As Well As AGM-Batteries)
- Reserve Capacity, RC
- Sae
- Self-Discharge
- Sulfation
- Acid Density
- Discharge
- Stand-By Voltage
- Stand By Current Consumption
- Volt (V)
- Volvo Battery Analyzer 3100
- Surface Charging
- Design And Function
- BOSCH Me7.01 Engine Management System (B5254T2; 2004-2006)
- Design
- Ignition Switch
- Fuel Pump Control Module (Only Vehicles With Demand Controlled Fuel Pumps)
- Fuel Pump (Only Vehicles With Demand Controlled Fuel Pumps)
- Brake Light Switch
- Clutch Pedal Sensor (Manual Transmissions Only)
- Air Conditioning (A/C) Pressure Sensor
- Heated Oxygen Sensors (HO2S)
- Engine Coolant Temperature (ECT) Sensor
- Engine Cooling Fan (FC) / Engine Cooling Fan (FC) Control Module
- Cooling Fan For Control Modules, Turbocharger (TC) (Certain Markets Only)
- Mass Air Flow (MAF) Sensor (2002-2004)
- Mass Air Flow (MAF) Sensor (2005-)
- Manifold Absolute Pressure (MAP) Sensor, Intake (Turbocharged Engines Only, 2002-2004)
- Manifold Absolute Pressure (MAP) Sensor, Intake (Turbocharged Engines Only, 2005-)
- Leak Diagnostic Unit (Certain Markets Only)
- Outside Temperature Sensor
- Engine Speed (RPM) Sensor
- Camshaft Sensor
- Knock Sensor (KS)
- Electronic Throttle Unit
- Throttle Position (TP) Sensor
- Accelerator Pedal (AP) Position Sensor
- Engine Coolant Level Sensor
- Temperature Sensor, Intake (Turbocharged Engines Only, 2002-2004)
- Fuel Pressure Sensor / Fuel Temperature Sensor (Only Vehicles With Demand Controlled Fuel Pumps)
- Oil Level Sensor (2004-, Certain Markets And Models Only)
- Main Relay (System Relay)
- Air Conditioning (A/C) Relay
- Fuel Pump (FP) Relay, (2002-2004)
- Injectors
- Evaporative Emission System (EVAP) Valve
- Camshaft Reset Valve (Continuous Variable Valve Timing (CVVT))
- Turbocharger (TC) Control Valve
- Ignition Coils
- Emissions Warning Lamp
- Diagnostic Functions
- Overview
- Misfire Diagnostic
- Camshaft Diagnostics (CVVT)
- Leak Diagnostics (Certain Markets Only)
- Heated Oxygen Sensor (HO2S) Diagnostic
- Three-Way Catalytic Converter (TWC) Diagnostics
- Fuel Pressure Regulation, Diagnostics (Only Vehicles With Demand Controlled Fuel Pumps)
- Oil Level Sensor, Diagnostics (2004-, Certain Markets And Models Only)
- Leak Diagnostics, Improved Version (2002-)
- Leak Diagnostics, Original Version (-2004)
- Leak Diagnostics, Original Version (2005-)
- Downloading Software And Replacing The Control Module
- Function
- System Overview
- Design
- BOSCH Me7.01 Engine Management System (B6294S2; B6294T; 2002-2006)
- Brake Control System (1999-2001)
- ABS Diagnostic Functions
- Calibration DSTC
- Design
- Function
- Software Downloading
- System Overview
- Brake Control System (2002-2006)
- Central Electronic Module (CEM) (1999-2004)
- Design
- Headlamps
- Parking Lights / License Plate Lighting
- Headlamp Range Adjustment (Certain Markets)
- Automatic Range Adjustment (Bi-Xenon)
- Front Fog Lamps
- Turn Signal Lamps / Hazard Warning Signal Flashers
- High-Mounted Stop Lamp (S80)
- Courtesy Lighting / Key Lighting / Glove Compartment Lighting
- Horn
- Starter Motor
- Rear Window Lift Mechanisms
- Fuel Pump
- Washer / Wipers
- Heated Seats (Certain Markets)
- Speed Sensitive Power Steering
- Diagnostic Functions
- Downloading Software And Replacing The Control Module
- Function
- Headlamps
- Parking Lights / License Plate Lighting
- Headlamp Range Adjustment (Certain Markets)
- Automatic Range Adjustment (Bi-Xenon)
- Front Fog Lamps
- Turn Signal Lamps / Hazard Warning Signal Flashers
- High-Mounted Stop Lamp (S80)
- Courtesy Lighting / Key Lighting / Glove Compartment Lighting
- Horn
- Starter Motor
- Rear Window Lift Mechanisms/Child Lock
- Fuel Pump
- Wiper / Washers For The Windshield And Headlamps
- Heated Seats (Certain Markets)
- Speed Sensitive Power Steering
- System Overview
- Design
- Central Electronic Module (CEM) (2005-2006)
- Design
- Generator (GEN) (Alternator Control Module (ACM))
- Current Limiting
- Steering Wheel Module (SWM)
- Steering Wheel Buttons
- Headlamps
- Headlamp Range Adjustment (Certain Markets)
- Automatic Range Adjustment (Bi-Xenon)
- Front Fog Lamps
- Front Parking Lamps
- Turn Signal Lamps / Hazard Warning Signal Flashers
- High Level Stop Lamp
- Courtesy Lighting / Key Lighting / Glove Compartment Lighting
- Horn
- Fuel Pump
- Fuel Level (Gasoline/Diesel)
- Washer / Wipers
- Starter Motor
- Speed Sensitive Power Steering
- Additional Heater (Diesel Engines Only)
- Parking Heater (Optional Extra)
- Twilight Sensor
- Sun Sensor (Electronic Climate Control Only)
- Blind Spot Information System (BLIS)
- Diagnostic Functions
- Notes
- Diagnostic Trouble Codes (DTCs)
- Reading And Erasing Diagnostic Trouble Codes (DTCs)
- Reading Off The Control Module Identification
- Reading Off Extended Diagnostic Trouble Code (DTC) Information
- Reading Off The Parameter Values
- Activating Components And Functions
- Reading Off And Programming Data
- Programming Keys
- Description Of Frozen Values, Central Electronic Module (CEM)
- Downloading Software And Replacing The Control Module
- Function
- Generator (GEN) (Alternator Control Module (ACM))
- Current Limiting
- Charge Voltage
- Controlling Functions And Menu Selection Using The Steering Wheel Buttons
- Trip Computer And Displaying/Erasing Text Messages
- Headlamps
- Headlamp Range Adjustment (Certain Markets)
- Automatic Range Adjustment (Bi-Xenon)
- Front Fog Lamps
- Front Parking Lamps
- Turn Signal Lamps / Hazard Warning Signal Flashers
- High Level Stop Lamp
- Courtesy Lighting / Key Lighting / Glove Compartment Lighting
- Horn
- Fuel Pump
- Fuel Level (Gasoline/Diesel)
- Wipers / Washers
- Starter Motor
- Speed Sensitive Power Steering
- Description Of Function Of The Operating Status Of The Heater
- Fuel Driven Parking Heater
- Electrical Heater With Timer Function
- Residual Heater
- Additional Heater
- Additional Heater And Parking Heater
- Starting The Heater Remotely
- Blind Spot Information System (BLIS)
- System Overview
- Design
- Central Locking (1999-2004)
- Signals
- System Description
- System Overview
- Location Of Components
- Locking System
- Initiation
- Function
- Locking And Unlocking Doors
- Locking And Unlocking The Fuel Tank Filler Cover, Modelswithoutfuel Tank Filler Cover Opening Via Remote Switch
- Locking And Unlocking The Fuel Tank Filler Cover, Modelswithfuel Tank Filler Cover Opening Via Remote Switch (Market Dependent)
- Opening And Unlocking The Trunk
- Automatic Functions
- Deadlocked (Market Dependent)
- Two Step Unlocking (Market Dependent)
- Power Child Lock (Option)
- Valet Locking (Option)
- Acknowledgment (Market Dependent)
- Central Locking (2005-2006)