Engine Controls - 8.1L
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Controls
- Diagnostic System Check - Engine Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Scan Tool Output Controls - Engine Controls
- Diagnostic Trouble Code (DTC) List
- DTC P0102
- DTC P0103
- DTC P0107
- DTC P0108
- DTC P0112
- DTC P0113
- DTC P0117
- DTC P0118
- DTC P0131 or P0151
- DTC P0132 or P0152
- DTC P0134 or P0154
- DTC P0200
- DTC P0230
- DTC P0325
- DTC P0327 or P0332
- DTC P0335
- DTC P0336
- DTC P0341
- DTC P0342
- DTC P0343
- DTC P0351-P0358
- DTC P0404
- DTC P0405
- DTC P0443
- DTC P0506 or P0507
- DTC P0601-P0607, P1600, P1621, P1627, P1680, P1681, or P1683
- DTC P0650
- DTC P1111
- DTC P1112
- DTC P1114
- DTC P1115
- DTC P1120
- DTC P1125
- DTC P1220
- DTC P1221
- DTC P1275
- DTC P1276
- DTC P1280
- DTC P1281
- DTC P1285
- DTC P1286
- DTC P1336
- DTC P1404
- DTC P1514
- DTC P1515
- DTC P1516
- DTC P1517
- DTC P1518
- DTC P1635
- DTC P1639
- Symptoms - Engine Controls
- Intermittent Conditions
- Hard Start
- Surges/Chuggles
- Lack of Power, Sluggishness, or Sponginess
- Detonation/Spark Knock
- Hesitation, Sag, Stumble
- Cuts Out, Misses
- Poor Fuel Economy
- Poor Fuel Fill Quality
- Rough, Unstable, or Incorrect Idle and Stalling
- Dieseling, Run-On
- Backfire
- Engine Cranks but Does Not Run
- Fuel Pump Electrical Circuit Diagnosis
- Fuel System Diagnosis
- Fuel Injector Coil Test
- Fuel Injector Balance Test with Special Tool
- Fuel Injector Balance Test with Tech 2
- Fuel Tank Leak Test
- Alcohol/Contaminants-in-Fuel Diagnosis
- Electronic Ignition (EI) System Diagnosis
- Repair Instructions
- Powertrain Control Module (PCM) Replacement
- Throttle Actuator Control (TAC) Module Replacement
- Powertrain Control Module (PCM) Programming (On-Board)
- CKP System Variation Learn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor Replacement
- Manifold Absolute Pressure (MAP) Sensor Replacement
- Heated Oxygen Sensor (HO2S) Replacement Bank 1 Sensor 1
- Heated Oxygen Sensor (HO2S) Replacement Bank 2 Sensor 1
- Accelerator Pedal Position (APP) Sensor Replacement
- Throttle Body Assembly Replacement
- Throttle Body Cleaning Procedure
- Fuel Pressure Relief Procedure
- Fuel Pressure Gage Installation and Removal
- Quick Connect Fitting(s) Service (Metal Collar)
- Quick Connect Fitting(s) Service (Plastic Collar)
- Fuel Filter Replacement
- Fuel Tank Draining Procedure
- Fuel Tank Replacement (Side)
- Fuel Tank Replacement (Rear)
- Fuel Level Sensor Replacement
- Fuel Strainer Replacement
- Fuel Tank Pump Module Replacement
- Fuel Balance Pump Replacement
- Filler Tube Replacement
- Fuel Sender Assembly Replacement
- Fuel Hose/Pipes Replacement - Filter to Engine
- Fuel Hose/Pipes Replacement - Filter to Tank
- Fuel System Cleaning
- Fuel Pressure Connection Valve Replacement
- Fuel Rail Assembly Replacement
- Fuel Pressure Regulator Replacement
- Fuel Injector Replacement
- Evaporative Emission (EVAP) Canister Purge Valve Replacement
- Evaporative Emission (EVAP) Canister Vent Valve Replacement
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Engine
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Canister/Fuel Tank (Canister - Chassis)
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Canister/Fuel Tank (Chassis - Fuel Tank)
- Evaporative Emission (EVAP) Canister Replacement
- Evaporative Emission (EVAP) System Cleaning
- Ignition Coil(s) Replacement
- Spark Plug Wire Inspection
- Spark Plug Wire Replacement
- Spark Plug Inspection
- Spark Plug Replacement
- Crankshaft Position (CKP) Sensor Replacement
- Camshaft Position (CMP) Sensor Replacement
- Knock Sensor (KS) 1 Replacement
- Knock Sensor (KS) 2 Replacement
- Exhaust Gas Recirculation (EGR) Valve Replacement
- Exhaust Gas Recirculation (EGR) Valve Bracket Replacement
- Exhaust Gas Recirculation (EGR) Pipe Replacement
- Exhaust Gas Recirculation (EGR) System Cleaning
- Intake Air Resonator Replacement
- Air Cleaner Element Replacement
- Air Cleaner Assembly Replacement
- Description and Operation
- Powertrain Control Module (PCM) Description
- Service Programming System (SPS) Description
- Throttle Actuator Control (TAC) System Description
- Fuel System Description
- Fuel System Overview
- Rear-Mounted Fuel Tank - If Equipped
- Side-Mounted Fuel Tank - If Equipped
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Balance Pump - If Equipped
- Fuel Strainer
- Fuel Filter
- Fuel Feed and Return Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator Assembly
- Fuel Metering Modes of Operation
- Starting Mode
- Clear Flood Mode
- Run Mode
- Acceleration Mode
- Deceleration Mode
- Battery Voltage Correction Mode
- Fuel Cutoff Mode
- Evaporative Emission (EVAP) Control System Description
- Electronic Ignition (EI) System Description
- Knock Sensor (KS) System Description
- Exhaust Gas Recirculation (EGR) System Description
- Air Intake System Description
- Special Tools and Equipment